| |
Food Facility Inspection Report |
|
|
Bucks County Department of Health
Health Building, Neshaminy Manor Center
Doylestown, PA 18901
(215) 345-3318
|
Total Violations |
3 |
Date of Inspection |
06/15/2023 |
| Risk Violations Count |
2 |
Inspection Time |
01.0 |
| Arrival Time |
11:58 |
Recommended for License |
YES |
| Travel Time |
00.1 |
Facility Closure |
NO |
|
Food Facility
BARBIE'S SOFT PRETZELS |
Address
2150 S EAGLE RD |
City/State
NEWTOWN, PA |
Zip Code
18940 |
Telephone
(215) 579-9664 |
Facility ID #
29F032 |
Owner
IVAN L. STOLTZFUS |
Purpose of Inspection
Initial |
License Type
Permanent |
Risk Category
2 |
|
FOODBORNE ILLNESS RISK FACTORS AND PUBLIC HEALTH INTERVENTIONS
|
|
IN=in compliance
OUT=not in compliance
N/O=not observed
N/A=not applicable
|
|
COS=corrected on-site during inspection
R=repeat violation
|
|
|
| Compliance Status |
COS |
R |
| Demonstration of Knowledge |
| 1 |
IN |
Certification by accredited program, compliance with Code, or correct responses |
|
|
| Employee Health |
| 2 |
IN |
Management awareness; policy present |
|
|
| 3 |
IN |
Proper use of reporting; restriction & exclusion |
|
|
| Good Hygienic Practices |
| 4 |
IN |
Proper eating, tasting, drinking, or tobacco use |
|
|
| 5 |
IN |
No discharge from eyes, nose, and mouth |
|
|
| Preventing Contamination by Hazards |
| 6 |
IN |
Hands clean & properly washed |
|
|
| 7 |
IN |
No bare hand contact with RTE foods or approved alternate method properly followed |
|
|
| 8 |
IN |
Adequate handwashing facilities supplied & accessible |
|
|
| Approved Source |
| 9 |
IN |
Food obtained from approved source |
|
|
| 10 |
IN |
Food received at proper temperature |
|
|
| 11 |
IN |
Food in good condition, safe, & unadulterated |
|
|
| 12 |
N/A |
Required records available: shellstock tags, parasite destruction |
|
|
| Protection from Contamination |
| 13 |
OUT |
Food separated & protected |
|
|
| 14 |
IN |
Food-contact surfaces: cleaned & sanitized |
|
|
| 15 |
IN |
Proper disposition of returned, previously served, reconditioned, & unsafe food |
|
|
|
|
| Compliance Status |
COS |
R |
| Potentially Hazardous Food Time/Temperature |
| 16 |
IN |
Proper cooking time & temperature |
|
|
| 17 |
IN |
Proper reheating procedures for hot holding |
|
|
| 18 |
OUT |
Proper cooling time & temperature |
|
|
| 19 |
IN |
Proper hot holding temperature |
|
|
| 20 |
IN |
Proper cold holding temperature |
|
|
| 21 |
IN |
Proper date marking & disposition |
|
|
| 22 |
IN |
Time as a public health control; procedures & record |
|
|
| Consumer Advisory |
| 23 |
N/A |
Consumer advisory provided for raw or undercooked foods |
|
|
| Highly Susceptible Populations |
| 24 |
N/A |
Pasteurized foods used; prohibited foods not offered |
|
|
| Chemical |
| 25 |
N/A |
Food additives: approved & properly used |
|
|
| 26 |
IN |
Toxic substances properly identified, stored & used |
|
|
| Conformance with Approved Procedure |
| 27 |
N/A |
Compliance with variance, specialized process, & HACCP plan |
|
|
Risk factors are improper practices or procedures identified as the most
prevalent contributing factors of foodborne illness or injury. Public Health
Interventions are control measures to prevent foodborne illness or injury. * - Critical Item Requiring Immediate Action
|
|
| GOOD RETAIL PRACTICES |
Good Retail Practices are preventative measures to control the addition of pathogens,
chemicals, and physical objects into foods.
|
|
| Compliance Status |
COS |
R |
| Safe Food and Water |
| 28 |
IN |
Pasteurized eggs used where required |
|
|
| 29 |
IN |
Water & ice from approved source |
|
|
| 30 |
IN |
Variance obtained for specialized processing methods |
|
|
| Food Temperature Control |
| 31 |
IN |
Proper cooling methods used; adequate equipment for temperature control |
|
|
| 32 |
IN |
Plant food properly cooked for hot holding |
|
|
| 33 |
IN |
Approved thawing methods used |
|
|
| 34 |
IN |
Thermometer provided & accurate |
|
|
| 35 |
IN |
Food properly labeled; original container |
|
|
| Prevention of Food Contamination |
| 36 |
IN |
Insects, rodents & animals not present; no unauthorized persons |
|
|
| 37 |
IN |
Contamination prevented during food preparation, storage & display |
|
|
| 38 |
IN |
Personal cleanliness |
|
|
| 39 |
IN |
Wiping cloths: properly used & stored |
|
|
| 40 |
IN |
Washing fruit & vegetables |
|
|
|
|
| Compliance Status |
COS |
R |
| Proper Use of Utensils |
| 41 |
IN |
In-use utensils: properly stored |
|
|
| 42 |
IN |
Utensils, equipment & linens: properly stored, dried & handled |
|
|
| 43 |
IN |
Single-use & single-service articles: properly stored & used |
|
|
| 44 |
IN |
Gloves used properly |
|
|
| Utensils, Equipment and Vending |
| 45 |
IN |
Food & non-food contact surfaces cleanable, properly designed, constructed, & used |
|
|
| 46 |
IN |
Warewashing facilities: installed, maintained, & used; test strips |
|
|
| 47 |
IN |
Non-food contact surfaces clean |
|
|
| Physical Facilities |
| 48 |
IN |
Hot & cold water available; adequate pressure |
|
|
| 49 |
OUT |
Plumbing installed; proper backflow devices |
|
|
| 50 |
IN |
Sewage & waste water properly disposed |
|
|
| 51 |
IN |
Toilet facilities: properly constructed, supplied, & cleaned |
|
|
| 52 |
IN |
Garbage & refuse properly disposed; facilities maintained |
|
|
| 53 |
IN |
Physical facilities installed, maintained, & clean |
|
|
| 54 |
IN |
Adequate ventilation & lighting; designated areas used |
|
|
|
|
|
|
|
|
| |
Food Facility Inspection Report |
|
|
Bucks County Department of Health
Health Building, Neshaminy Manor Center
Doylestown, PA 18901
(215) 345-3318
|
Date of Inspection |
06/15/2023 |
| Arrival Time |
11:58 |
| Recommended for License |
YES |
| Facility Closure |
NO |
|
Facility
Barbie's Soft Pretzels |
Address
2150 S EAGLE RD |
City/State
NEWTOWN, PA |
Zip Code
18940 |
Telephone
(215) 579-9664 |
Facility ID #
29F032 |
Owner
Ivan L. Stoltzfus |
Purpose of Inspection
Initial |
License Type
Permanent |
Risk Category
2 |
|
|
TEMPERATURE OBSERVATIONS
|
| Item/Location |
Temp |
Item/Location |
Temp |
Item/Location |
Temp |
| Ambient/Stand up refrigerator |
38 ° F |
Scrambled Egg/Stand up refrigerator |
60 ° F |
Cooked Bacon/Stand up refrigerator |
50 ° F |
| Ambient/Ice Cream Freezer |
-10 ° F |
Ambient/Prep Unit |
25 ° F |
Hot Dog/Prep Unit |
41 ° F |
| Stuffed Buffalo Pretzel/Hot-Hold Unit |
140 ° F |
|
|
|
|
|
|
|
|
|
|
|
| OBSERVATIONS AND CORRECTIVE ACTIONS |
Item
Number |
Violations cited in this report must be corrected within the time frames below.
|
|
*13
|
*Several products being held in the stand up refrigerator and prep unit are not being covered, and cheese scraps were just sitting on the shelf unprotected. Cover and store all products properly in refrigerators to prevent contamination. The cheese scraps were discared. New Violation.
|
|
*18
|
*Both scrambled eggs and cooked bacon in the stand up refrigerator were measureing temperatures of 60 and 50 degrees F.
Cooked time/temperature control for safety (TCS) food shall be cooled as follows:
(1) Within 2 hours, from 135°F to 70°F.
(2) Within 6 hours, from 135°F to 41°F or less
Time/temperature control for safety (TCS) food shall be cooled within 4 hours to 41°F, if prepared from ingredients at ambient room temperatures.
Move these items to shallower containers to allow faster, safer cooling. New Violation.
|
|
49
|
*There is a slight leak from the faucet of the hand sink.
Fix and manintain. New Violation.
|
|
|
|
|
|
|
|
General Remarks
|
Note:
*The Pepsi and Orange soda souts need to be cleaned - slight build up of debris.
*Think about a possible splash guard on the hand washing sink to prevent splashes on the prep table.
*This report will be mailed to owner's home.
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|